The occurrence of sulfur in coal direct liquefaction residue affects its further high quality and high value utilization. Electrochemical desulfurization is characterized by mild reaction conditions, simple operation, easy separation of sulfur conversion products and little influence on the properties of the liquefied residue. An anodic electrolytic oxidation desulphurization experiment was ...
WhatsApp: +86 18203695377
Hydrodesulfurization (HDS), also called hydrotreatment or hydrotreating, is a catalytic chemical process widely used to remove sulfur (S) from natural gas and from refined petroleum products, such as gasoline or petrol, jet fuel, kerosene, diesel fuel, and fuel oils. The purpose of removing the sulfur, and creating products such as ultralowsulfur diesel, is to reduce the sulfur dioxide (SO 2 ...
WhatsApp: +86 18203695377
In this study, coal fly ash was functionalized, using a simple onestep process (loading with Al3+ and sulfonation), to yield a solid acid catalyst (S/AlCFA) with strong acid sites. The catalyst was then used to produce furfural from xylose in a biphasic system (H2O(NaCl)/tetrahydrofuran). The furfural yield reached 82% at 180 °C60 min with catalyst/xylose ratio of : (w/w).
WhatsApp: +86 18203695377
Sulfur in coal exists in inorganic and organic forms, the former being mostly pyritic sulfur. Total sulfur contents in major coalfields are in the range of roughly wt%. In coal combustion, to generate electric power and process heat, the sulfur is emitted as SO2, which is seen as one of the main causes of acid rain. This effect has led ...
WhatsApp: +86 18203695377
During the project of the technical transformation of a 75t/h CFB boiler, the desulphurization rate, the utilization ratio of CaO, the sintered ratio of CaO, etc. can be got, by the calcium conservation and sulfur conservation according to the analysis of coal and...
WhatsApp: +86 18203695377
The process of bacterial coal desulfurization led to increase in calorific value showing advantage over conventional treatment methods. ... Effect of native bacteria Sinomonas flava 1C and Acidithiobacillus ferrooxidans on desulphurization of Meghalaya coal and its combustion properties. Fuel, 117 (2014), pp. 415421.
WhatsApp: +86 18203695377
According to the enlargement of fine particles by heterogeneous condensation and typical technology of wet flue gas desulphurization (WFGD) system, a novel process is proposed in this paper to remove fine particles from coalfired flue gas in WFGD system which use limestone as desulfurizer.
WhatsApp: +86 18203695377
1. Introduction. Coal is the dominant fossil energy in China and continues to play an important role in the next few decades [1].However, during coal direct utilization processes, some sulfurcontaining gases (H 2 S, SO 2 and COS, etc) would release into the air, and cause some seriously environmental pollution [2].Thus, some highsulfur coals need to be desulfurized before their utilization.
WhatsApp: +86 18203695377
The flue gas desulfurization wastewater is highly saline and has too many refractory pollutants to be recycled during the desulfurization process of the coalfired heating plant. Given that waste heat is abundant in coalfired heating plants, a thermal ...
WhatsApp: +86 18203695377
To reduce the risk of spontaneous combustion during coal storage and transportation, microbial desulfurization technology is used to reduce the content of inorganic sulfur in coal. A strain of Aciditithiobacillus ferrooxidans was purified from coal mine water in Datong, Shanxi Province, and its desulfurization test conditions were optimized. Taking the inorganic sulfur removal rate of coal as ...
WhatsApp: +86 18203695377
In this pretreatment process, the coal layer thickness and length of stay in the reaction cavity should be controlled, the sulphurcontaining gases within the cavity should be exported timely, and it should be ensured that the temperature of the coal sample after pretreatment was 150250 °C. ... (1996) Microwave desulphurization of coal ...
WhatsApp: +86 18203695377
Desulfurization techniques process and future challenges for commercial of crude oil products: Review ... and challenges of existing HDS processes. The second part examines recent advances in desulphurization techniques and future challenges for commercial, that are being researched around the world and are regulating the manufacture of a new ...
WhatsApp: +86 18203695377
For the coal pyrolysis process, unstable sulfur compounds will decompose, generate sulfur radicals and release as sulfurcontaining gases, this becomes the main pathway for sulfur removal. Coal properties, minerals and sulfur forms in coal, and pyrolysis conditions such as temperature, atmosphere, and the mass transfer, are the main factors ...
WhatsApp: +86 18203695377![Desulfurization of coal using four ionic liquids with [HSO4]−](/rnudpye/250.jpg)
The combined irradiation process of ultrasonic and microwave energy is observed to be the most effective for the beneficiation of highsulfur coal than the single process. The result showed a maximum of % and % ash (mineral matter) removal from the coal samples by microwave followed by an ultrasonic process.
WhatsApp: +86 18203695377![Process for coal desulfurization. [use of microwave energy]](/rnudpye/51.jpg)
A process for coal desulfurization generates extremely low amounts of heat from microwave energy to induce thermochemical, insitu, reactions to liberate sulfur in the form of stable gaseous species, such as H/sub 2/S, COS and SO/sub 2/. Inventors:
WhatsApp: +86 18203695377
This process, termed MoltenCausticLeaching, or the Gravimelt Process, results in removal of 9099% of the coal inorganic and organic sulfur as well as 9599% of the coal mineral matter. The product coal meets all current air pollution control standards for sulfur and ash emissions, and has an increased heat content, usually in the ...
WhatsApp: +86 18203695377
article{osti_, title = {Coal desulfurization}, author = {Meyers, R A and Van Nice, L J and Santy, M J}, abstractNote = {The Meyers process of removing pyritic sulfur from coal chemically before it is burned is presented. The process involves the treatment of crushed coal with an aqueous leaching solution of ferric sulfate which reacts with the coal pyrites to yield soluable ferrous ...
WhatsApp: +86 18203695377
Flue gas desulfurization gypsum (FGDG) is an industrial byproduct generated during the flue gas desulfurization process in coalfired power plants. Flue gas desulfurization systems have been used to limit the release of sulfur dioxide from coalfired power plants since the late 1960s, but in the past decade the production of FGDG has ...
WhatsApp: +86 18203695377
How to reduce the energy consumption of the rotary kilnelectric furnace (RKEF) process has become an important issue for the stainless steel industry. The aim of this study is to reduce the energy consumption of ferronickel production from saprolite nickel laterite in the RKEF process. The effects of the slag binary basicity, FeO content, and Cr2O3 content on the melting temperature and ...
WhatsApp: +86 18203695377
Experimental process and equipment Coal samples pretreatment process. To reduce the impact of soluble impurities in the coal sample on the microbial desulfurization effect, it is necessary to pretreat the coal sample (Chen et al., 2021; Rout et al., 2022), the steps were shown in Figure 3. Appropriate amount of coal sample was put ...
WhatsApp: +86 18203695377
Optimization Mechanism of Permeability Response Behavior of Fine Coal. The absorption process of microwave energy in fine coal is a kind of electromagnetic response process. The electromagnetic wave energy was converted into heat energy so that the microwave energy would be absorbed through dielectric and magnetic losses.
WhatsApp: +86 18203695377
With the increasingly prominent global energy and environmental problems, more and more enterprises have been required to desulfurize the exhausted gases. Different enterprises have different demands for the desulfurization process, thus the choice of desulfurization process methods has become a focus of attention. Since the evaluation of the desulfurization process involves many factors, this ...
WhatsApp: +86 18203695377
A series of mesoporous xLayMn/KIT6 sorbents with different La/Mn atomic ratios were fabricated by a solgel method and their desulphurization properties in hot coal gas were investigated at 700 ...
WhatsApp: +86 18203695377
A material supplier from Belgium would like to produce limestone powder for his custome...
India is rich in various mineral resources and it is an important mineral processing market
Copyright © 2023 GMC Co., Ltd. SiteMap
