When the consumed sulphur in coal is in the form of sulphur dioxide at the end of combustion, it reacts with water at high altitudes. Moreover, it goes down to the earth in the form of sulphuric acid, as well as damaging plants. The corrosive harmful impact on industrial plants is the removal of the sulphur in the coal when it is environmental.
WhatsApp: +86 18203695377
The flue gas desulfurization process in coalfired power plants is energy and resourceintensive but the ecoefficiency of this process has scarcely been considered. Given the fluctuating unit load and complex desulfurization mechanism, optimizing the desulfurization system based on the traditional mechanistic model poses a great challenge. In this regard, the present study optimized the eco ...
WhatsApp: +86 18203695377
Sulfur dioxide is the most important precursor of acid rain and one of the major contaminants generated from coalfired power plants. Currently, the limestonegypsum wet fluegas desulfurization (WFGD) system is the most widely used method for removal of SO 2 from powerplant exhaust fumes. However, the gypsum byproduct of limestonegypsum WFGD ...
WhatsApp: +86 18203695377
Mechanism of Pyrite Microbial Desulfurization. The oxidation process of coal conversion is possible by microorganisms after getting influenced by the polyfunctional coal structure and this process usually depends on two main factors: size or shape of coal and surface properties of microorganisms (Konishi et al. 1990). The morphology and ...
WhatsApp: +86 18203695377
Coal desulfurization has come a long way in the past 15 years, and chemical desulfurization has been at the forefront of this progression. Unfortunately, unless some new technique is developed, the chemical desulfurization processes appears to be at a stalemate. ... The Meyers process of removing pyritic sulfur from coal chemically before it ...
WhatsApp: +86 18203695377
Desulfurization systems in coalfired power stations often suffer the problem of high operating costs caused by a ruleofthumb control strategy, which implies great potential for optimization of the operation. ... In this paper, an operation strategy optimization method for the desulfurization process is proposed based on a data mining ...
WhatsApp: +86 18203695377
As a typical industrial byproduct during the flue gas desulfurization process of coalfired, flue gas desulfurization ash (FGDA) with alkali mineral can facilitate the water damage resistance of asphalt mixtures. However, low density and high hydrophilic coefficient of FGDA limit its improvement effect. Hence, the comprehensive moisture ...
WhatsApp: +86 18203695377
The increasing use of highsulfur coal contradicts with the stringent environmental pressure in metallurgical industry. Microwave has been confirmed to have efficient effect for coal desulfurization. However, the removal behavior of thiophenic sulfur, as the most difficult sulfur to remove from coal, is still unclear in microwave field. In this work, the feasibility of removing thiophenic ...
WhatsApp: +86 18203695377
During the desulfurization process of coalfired power plants, there are many related parameters that affect the desulfurization efficiency. So it is very difficult to measure the desulfurization efficiency directly. In this paper, in order to reflect the relationship between monitoring process parameters and desulfurization efficiency better, a novel prediction model of desulfurization ...
WhatsApp: +86 18203695377
An effective precombustion coal desulfurization process should ideally be capable of removing both organic and inorganic sulfur. A variety of techniques exist for the removal of inorganic sulfur from coal, but there is currently no costeffective method for the precombustion removal of organic sulfur. Recent developments have demonstrated ...
WhatsApp: +86 18203695377
environment, the desulfurization and denitration of flue gas in the combustion process of coal has become an important step. T his work summarizes the desulfur ization and denitration
WhatsApp: +86 18203695377
In this work, the desulfurization process of highsulfur anthracite coal is discussed, and the desulfurization method of "reduced iron powder + heat treatment + magnetic separation" (named "RIHM") is designed. ... In this study, a highsulfur coal desulfurization experiment was carried out for highsulfur raw coal to reveal the internal ...
WhatsApp: +86 18203695377
This work was conducted through field tests on a coalfired circulating fluidized bed boiler with a condensation scrubber (CS) for flue gas waste heat recovery installed behind the wet flue gas desulfurization (WFGD) scrubber. Levels of multiple pollutants were investigated along the various flue gas devices of the boiler, with the CS being the ...
WhatsApp: +86 18203695377
Abstract. Most coal requires some preparation before use. Preparation may range from simply crushing to provide a size consist suitable for certain types of boilers to extensive size reduction and cleaning to remove sulfur and ashforming mineral matter. At present, coal cleaning is accomplished through physical separation of particles low in ...
WhatsApp: +86 18203695377
The FlueGas Desulfurization (FGD) process utilizes a set of technologies to remove sulfur dioxide (SO 2) from the flue gas emissions of coalfired power systems were developed as a response to the exhaust flue gases from fossil fuelburning plants, principally coalburning, that posed both an environmental and human health hazard.
WhatsApp: +86 18203695377
The desulfurization process took place at a pH of 35, the coalparticle size was 7545 μm, the pulp density was 5%, the temperature was 35°C, and the incubation time was 8 h. Chemical studies also revealed a decrease in the ash content and an increase in the calorific value of coal from 6219 cal/g to 6406 and 6315 cal/g, which indicated ...
WhatsApp: +86 18203695377
This study investigated the characteristics of mercury emitted from a largescale coalfired power plant in Taiwan via intensive sampling campaigns. The air pollution control devices equipped in this coalfired power plant include selective catalytic reduction, fabric filter and seawater flue gas desulfurization. During three sampling campaigns, mercury concentrations emitted from this large ...
WhatsApp: +86 18203695377
The process of sulfur removal by microbes is carried out by enzymes and is considerably influenced by different factors, including pH, temperature, nutrient composition, shaking or standing condition, coal types, and most importantly type of microorganisms used.
WhatsApp: +86 18203695377
The combined effect of desulfurization and ash removal in the process of coal desulfurization by microwave with peroxyacetic acid was determined by evaluating variations in minerals and sulfur forms using Xray diffraction and Xray photoelectron spectroscopy. Dielectric properties of minerals or organic sulfur functional groups in coal were studied utilizing a vector network analyzer in the ...
WhatsApp: +86 18203695377
XANES was used to analyze the change of sulfur forms in the desulfurization process of high organic sulfur coal under microwave heating and conventional heating conditions. The effects of microwave fields on the molecular properties, bond strength and reaction kinetic of organic sulfurcontaining groups were studied by quantum chemical calculation.
WhatsApp: +86 18203695377
The flue gas desulfurization solids in the dry process (DFGDS) are the newly formed CaSO 4 and the unreacted excess of CaO. They are carried along with the coal FA out of the boiler, forming the end product (FA + DFGDS), which is highly alkaline due to the excess of CaO with respect to the initial SO 2 (Ca:S = ). Due to a low ...
WhatsApp: +86 18203695377
In 2010, Li and coworkers demonstrated an extremely rapid, convenient and mild coal desulfurization new process using sodium borohydride and 3141% reduction of total sulphur was achieved (Li et ...
WhatsApp: +86 18203695377
Abstract To explore the feasibility of organic sulfur removal using organic acids, oxalic acid, citric acid and ascorbic acid were selected as desulfurization reagents. Combined with microwave irradiation technology, desulfurization experiments of highsulfur coal treated with nitric acid were conducted. The orthogonal experimental results showed that the microwave synergistic citric acid ...
WhatsApp: +86 18203695377
Coal desulfurization The development and utilization of traditional coal plays a vital role in promoting social and economic development, but it has brought irreversible pollution to the ecological environment ( Zeng et al., 2021 ).
WhatsApp: +86 18203695377
A material supplier from Belgium would like to produce limestone powder for his custome...
India is rich in various mineral resources and it is an important mineral processing market
Copyright © 2023 GMC Co., Ltd. SiteMap
